(Essentially Similar to OSHA-20)
Tampa, FL 33605
866-829-6908
|
I – PRODUCT IDENTIFICATION CHEMICAL LABORATORIES INC. |
|
|
MANUFACTURER’S NAME AND ADDRESS 1917 E. HEMLOCK AVE TAMPA, FL 33605 |
|
|
CHEMICAL NAME CARBURETOR CLEANER |
CHEMICAL FORMULA CHLORINATED HYDROCARBON |
|
TRADE NAME AND SYNONYMS DEGREASER |
CHEMICAL FAMILY ALIPHATIC/CHLORINATED |
|
CAS REGISTRY NO.
|
DOT IDENTIFICATION NO. |
|
II – HAZARDOUS INGREDIENTS |
||
|
MATERIAL OR COMPONENT CHLORINATED SOLVENT ALIPHATIC SOLVENT |
%(wt) 20 80 |
TLV (Units) 300 300 |
III = PHYSICAL DATA |
|
|
BOILING POINT (°F) 180 |
SPECIFIC GRAVITY 1.20 |
|
VAPOR PRESSURE (mm Hg) UNKNOWN |
PERCENT, VOLATILE BY VOLUME (%) 100 |
|
VAPOR DENSITY(AIR=1)
|
EVAPORATION RATE UNKNOWN |
|
SOLUBILITY IN WATER NONE |
APPEARANCE AND ODOR THIN, CLEAR, CHEMICAL |
|
IV – FIRE AND EXPLOSIVE HAZARD DATA |
|
|
FLASH POINT (Method used) UNKNOWN |
FLAMMABLE
LIMITS Lower Upper
|
|
EXTINGUISHING MEDIA FOAM, CO2, DRY CHEMICALS, WATER FOG |
|
|
SPECIAL FIRE FIGHTING
PROCEDURES NONE |
|
|
UNUSUAL FIRE AND
EXPLOSION HAZARDS NONE, AVOID OPEN FLAMES, SMOKING |
|
|
V – REACTIVITY DATA |
||||||
| STABILITY |
UNSTABLE
|
CONDITIONS TO AVOID | ||||
|
STABLE
|
X | |||||
|
INCOMPATIBILITY (Material
to avoid) NONE |
||||||
|
HAZARDOUS DECOMPOSITION
PRODUCTS
|
||||||
| HAZARDOUS POLYMERIZATION |
MAY OCCUR
|
CONDITIONS TO AVOID | ||||
|
WILL NOT OCCUR
|
X |
|
||||
|
VI = HEALTH HAZARD DATA
|
||||||
|
OSHA PERMISSIBLE EXPOSURE
LIMIT 300 ppm |
||||||
|
|
||||||
|
EFFECTS OF OVEREXPOSURE . ALWAYS USE THIS PRODUCT IN WELL VENTILATED AREAS. |
||||||
|
INHALATION Nasal, respiratory irritation, signs of anesthesia |
||||||
|
SKIN CONTACT /
ABSORPTION
|
||||||
|
EYES:
|
||||||
| EMERGENCY AND FIRST AID PROCEDURES | ||||||
|
EYES AND SKIN Flush with plenty of water. Wash with soap and water. |
||||||
|
INHALATION Always use in well ventilated areas. |
||||||
|
INGESTION Harmful or fatal if swallowed, seek medical attention. |
||||||
|
VII – SPILL OR LEAK PROCEDURES
|
|
STEPS TO BE TAKEN IN CASE
MATERIAL IS RELEASED OR SPILLED Avoid open flames. Provide adequate ventilation. Flush with water and dispose all spilled liquids.
|
|
WASTE DISPOSAL METHOD According to local regulations. Same as above.
|
|
VIII – SPECIAL PROTECTION INFORMATION
|
|
SPECIFIC PERSONAL
PROTECTIVE EQUIPMENT RESPIRATORY
|
|
EYE Goggles |
|
SKIN Protective gloves |
|
OTHER Rubber apron |
|
VENTILATION REQUIREMENTS Maintain TLV limits |
|
IX – SPECIAL PRECAUTIONS
|
|
PRECAUTIONS TO BE TAKEN
IN HANDLING AND STORING Handle as combustible liquid.
|
|
OTHER PRECAUTIONS Keep in cool place.
|