(Essentially Similar to OSHA-20)
Tampa, FL 33605
1-866-809-6908
|
I – PRODUCT IDENTIFICATION CHEMICAL LABORATORIES INC. |
|
|
MANUFACTURER’S NAME AND ADDRESS 1917 E. HEMLOCK AVE TAMPA, FL 33605 |
|
|
CHEMICAL NAME Erusticator |
CHEMICAL FORMULA PROPRIETARY / H F & H2PO4 |
|
TRADE NAME AND SYNONYMS Rust Stain Remover |
CHEMICAL FAMILY
|
|
CAS REGISTRY NO. |
DOT IDENTIFICATION NO. |
|
II – HAZARDOUS INGREDIENTS |
||
|
MATERIAL OR COMPONENT Ammonium BiFlouride |
%(wt) 6 |
PEL (Units)
|
III = PHYSICAL DATA |
|
|
BOILING POINT (°F) 212 |
SPECIFIC GRAVITY
|
|
VAPOR PRESSURE (mm Hg)
|
PERCENT, VOLATILE BY VOLUME (%) 95 |
|
VAPOR DENSITY(AIR=1)
|
EVAPORATION RATE
|
|
SOLUBILITY IN WATER 100% |
APPEARANCE AND ODOR CLEAR – Acid Ph less than 1 |
|
IV – FIRE AND EXPLOSIVE HAZARD DATA |
|
|
FLASH POINT (Method used) NONE |
FLAMMABLE
LIMITS Lower Upper
|
|
EXTINGUISHING MEDIA N/A |
|
|
SPECIAL FIRE FIGHTING
PROCEDURES NONE |
|
|
UNUSUAL FIRE AND
EXPLOSION HAZARDS Exposure to heat yields hydrogen fluoride vapors |
|
|
V – REACTIVITY DATA |
||||||
| STABILITY |
UNSTABLE
|
CONDITIONS TO AVOID | ||||
|
STABLE
|
X | |||||
|
INCOMPATIBILITY (Material
to avoid) BASE METALS |
||||||
|
HAZARDOUS DECOMPOSITION
PRODUCTS Contact with most metals liberates hydrogen gas. |
||||||
| HAZARDOUS POLYMERIZATION |
MAY OCCUR
|
CONDITIONS TO AVOID
|
||||
|
WILL NOT OCCUR
|
X |
|
||||
|
VI = HEALTH HAZARD DATA
|
||||||
|
OSHA PERMISSIBLE EXPOSURE
LIMIT
|
||||||
|
|
||||||
|
EFFECTS OF OVEREXPOSURE
|
||||||
|
INHALATION Irritation to respiratory tract. |
||||||
|
SKIN CONTACT /
ABSORPTION May cause burns
|
||||||
|
EYES: Flush with water and get medical attention
|
||||||
| EMERGENCY AND FIRST AID PROCEDURES | ||||||
|
EYES AND SKIN Flush with plenty of water and get medical attention. |
||||||
|
INHALATION Remove to fresh air and get medical attention. |
||||||
|
INGESTION HIGHLY TOXIC - CORROSIVE TO TISSUE - Drink baking soda in water – Call Physician |
||||||
|
|
||||||
|
VII – SPILL OR LEAK PROCEDURES
|
|
STEPS TO BE TAKEN IN CASE
MATERIAL IS RELEASED OR SPILLED Wear protective equipment – Recover as much as possible and neutralize balance with soda ash.
|
|
WASTE DISPOSAL METHOD According to local ordinances.
|
|
VIII – SPECIAL PROTECTION INFORMATION
|
|
SPECIFIC PERSONAL
PROTECTIVE EQUIPMENT RESPIRATORY Supplied air |
|
EYE Face shield |
|
SKIN Protective gloves |
|
OTHER Impervious clothing |
|
VENTILATION REQUIREMENTS Normal |
|
IX – SPECIAL PRECAUTIONS
|
|
PRECAUTIONS TO BE TAKEN
IN HANDLING AND STORING Store in acid proof containers and keep closed. |
|
OTHER PRECAUTIONS
|